More wear found on tubes at ailing Cal nuke plant

Associated Press Modified: April 12, 2012 at 7:45 pm •  Published: April 12, 2012
Advertisement
;

LOS ANGELES (AP) — The operator of an idled nuclear plant on the California coast announced Thursday that more unusual wear has been found on tubing that carries radioactive water, the latest disclosure in a mystery involving the plant's steam generators.

Southern California Edison said in a statement that investigators at the San Onofre Nuclear Generating Station found additional damage on tubes in its Unit 2 generators that is similar to degradation in its sister reactor, Unit 3, though at a lower level.

Investigators had been puzzled why tube damage appeared different in the side-by-side units, even though the equipment is essentially identical.

The new findings show "all of the generators are exhibiting the same kind of wear, though the wear in unit 3 is more excessive than in Unit 2," Nuclear Regulatory Commission spokesman Victor Dricks said.

The seaside plant has been shut down for more than two months while federal regulators and company officials try to find out why tubing designed to withstand many years of use under high pressure has eroded at an unusual rate, in some cases rapidly.

The trouble began to unfold in late January, when the Unit 3 reactor was shut down as a precaution after a tube break. Traces of radiation escaped, but officials said there was no danger to workers or neighbors.

Unit 2 had been taken offline earlier that month for routine maintenance and refueling, but investigators later found unusual wear on tubing in both units.

The excessive tube wear has raised questions about the integrity and safety of replacement generators the company installed in a multimillion-dollar makeover in 2009 and 2010.

There are nearly 10,000 alloy tubes in each of the plant's four steam generators. The latest results show that two types of wear have occurred at both units — tubes are rubbing and vibrating against adjacent tubes, as well as against support structures inside the generators.

Previously, the heavy wear on Unit 2 tubing was limited to areas around bracing and supports.

It's not known, however, why that is happening. Now that similar damage has been witnessed in both units, it could help investigators pinpoint a cause.

The NRC has said the plant, located between Los Angeles and San Diego, will remain dark until the company determines the cause of the wear and fixes it. The company has said 321 heavily damaged tubes will be plugged and taken out of service at the two reactors, well within the margin to allow them to keep operating.

The company has said safety is its first priority.

| |

Advertisement


Trending Now



AROUND THE WEB

  1. 1
    Galveston medical examiner identifies Edmond runner who died at ‘Run Like a Diva‘ half marathon
  2. 2
    After nearly 20 years, Alfa Romeo returns to America
  3. 3
    Naya Rivera raged to 'Glee' producers: Lea Michele's out of control
  4. 4
    VIDEO: Kids try to figure out Walkman cassette players
  5. 5
    Man who plunged from Denver balcony ate 6 times recommended amount of pot cookie
+ show more