Fire suppression systems urged in all cargo planes

Associated Press Modified: November 28, 2012 at 2:33 pm •  Published: November 28, 2012
Advertisement
;

WASHINGTON (AP) — The government should require fire suppression systems in all cargo containers or compartments of planes to prevent the kind of ferocious in-flight blazes that have killed four cargo pilots over the past six years, federal accident investigators said Wednesday.

The National Transportation Safety Board didn't specify what kind of technology the Federal Aviation Administration should require airlines to install. But the board's letter to the FAA came a day after United Parcel Service said it has developed systems that can prevent or contain even fires in shipments of lithium batteries, which burn at very high temperatures.

Lithium batteries are suspected to have caused or contributed to the severity of the fire in the crashes of a UPS jumbo freight airplane in Dubai in 2010 and an Asiana Cargo plane off the coast of South Korea in 2011. In 2006, two UPS pilots were able to escape a plane shortly after landing in Philadelphia before it was consumed by flames. That plane also contained lithium batteries.

Current fire protection regulations for cargo planes are inadequate, according to the board's letter.

"These fires quickly grew out of control, leaving the crew with little time to get the aircraft on the ground," NTSB Chairman Deborah Hersman said in a statement. "Detection, suppression and containment systems can give crews more time and more options; the current approach is not safe enough."

FAA rules say airplane fire warning systems must be able to detect fire in a cargo container within a minute of its ignition. But the NTSB said its tests of two types of cargo containers showed a time lapse between ignition and detection ranging from 2 1/2 minutes to more than 18 minutes.

In the tests, the fires "grew very large, capable of causing significant damage to an aircraft" before they were detected, the letter said.

Current FAA regulations require halon gas fire suppression systems in below-deck cargo holds, but not in the main cargo compartment above deck. The main strategy for fighting fires above deck is to deprive them of oxygen by taking the plane to an altitude where depressurization is achieved.

In the case of the UPS plane that crashed in Dubai, however, there was a lapse of 2 1/2 minutes between detection of the fire and depressurization, which was enough time for the fire to damage the plane and affect the pilots' ability to control the aircraft, the NTSB said.

Also, halon systems don't work on fires involving lithium metal batteries, which are found in watches, calculators and a wide range of consumer goods.

Unlike other kinds of batteries, lithium metal batteries can spontaneously ignite if exposed to air. Also, the positive and negative poles in some lithium batteries are close together, leading more easily to short circuiting, which can cause a fire.

| |

Advertisement


Trending Now



AROUND THE WEB

  1. 1
    VIDEO: Kids try to figure out Walkman cassette players
  2. 2
    Man who plunged from Denver balcony ate 6 times recommended amount of pot cookie
  3. 3
    Chelsea Manning named Honorary Marshal in San Francisco's Gay Pride Parade
  4. 4
    'Scandal' serves up explosive season finale!
  5. 5
    South Korea ferry disaster: Rescued vice-principal found hanging from tree
+ show more